WPC & SPC

Green and environmentally friendly product
(Email: [email protected])

Products

How to Replace A Fiberglass Rotten Boat Deck | BDOutdoors ...

23 · Replacing a rotten boat deck is a fairly common task, and it’s a lot easier than you might think. Hopefully, when you bought your boat you gave it a thorough pre-purchase inspection and didn’t get any nasty surprises. But if you buy a fixer-upper or have an older boat you love and don’t want to part with, there’s a fair chance you’ll need to replace part or all of the rotten boat ...

Get price

Fibreglass boat repair – replacing stringers

29 · Now you have successfully replaced the stringer, all that’s left to do is replace the fibreglass skin and your deck will, once again, be fully supported. If you’ve got a repair you’re unsure about, visit WSI’s dedicated support page for video tutorials, guides and …

Get price

How to Repair a Stair Stringer at Home | Home Guides | SF G…

Stringer Repairs in Fiberglass Boats - Epoxyworks

Get price

Deck stringer repair

 · Deck stringer repair. aponder (Anthony Ponder, NACHI17040603) Septem, 11:17pm #1. Ok, so the stringer in the attached photo passes the “minimum inches wide” requirement, but surely this can’t be right. I’ve checked the books and mired through the internet and don’t see where stringer repairs are mentioned.

Get price

Quick Repair for Old Deck Stairs

31 · Cut a piece of scrap treated wood and sandwich your old wood with the new. Use deck screws to secure in place. If your old wood is rotten it will have to be torn out and replaced. One other fix before attaching the new stair tread was to protect the old stair riser from soaking up more water. A small piece of metal flashing does the trick.

Get price

Rotten Exterior Stair Case – PD Design Build

24 · Remove all rotten wood. Install pressure treated 2x blocking between the stringers (diagram 3) and sister new pressure treated 2xs onto the sides of the stringers (diagram 4). The sistered 2xs will provide a surface to attach your tread boards. Use screws not nails. Install blocking at the corners to stiffen the connection of the post to the stringer.

Get price

Are Rotten Stringers a concern? | Boating Forum

 · Ok, point being, stringers are the backbone of your boat. Rotten ones will affect the integrity of your boat and will cause a safety risk. When that risk turns into an event -- it will go bad, lives at risk, and unplanned financial losses. Save your cash for a better boat. Don't do what I did ! C.

Get price

OUTDOOR STAIRS

19 · Three waves of repair thus far, judging from the different woods used. Looks like fun. Don’t get much deck/stair repair so your ideas are welcome. The bottom flight has 48″W treads (2.5 x 11 = 3×12?) hung off metal stair backets on the non PT stringers. OK except these two. They have termite damage and one was secured with some deck screws.

Get price

OUTDOOR STAIRS

19 · Three waves of repair thus far, judging from the different woods used. Looks like fun. Don’t get much deck/stair repair so your ideas are welcome. The bottom flight has 48″W treads (2.5 x 11 = 3×12?) hung off metal stair backets on the non PT stringers. OK except these two. They have termite damage and one was secured with some deck screws.

Get price

Shipyard Project No. 4: Repair of Rotten Engine Stringer ...

30 · When Shane asked me if I wanted him and his guys to get on the rotten engine stringer repair, I said: “Nope. I’ve got this one.” As many of you may recall, back in 2015, Phillip and I discovered the stringers under our mast step had been rotting for some time.

Get price

deck

4 · I had a similar problem with stringers in direct contact with cement that had water runoff. I sawed off 1/2" from the bottom of each of four stringers,screwed in 2 1/2" stainless steel lag screws into the bottom of each stringer. Once back in place, backed out …

Get price

How To Find Rotten Stringers and Deck | Boating Forum ...

 · Most notice a rotten floor by feeling 'soft spots' that give when you walk over them. If you find soft spots in the deck, you have a pretty good chance of having rot below the deck, as boats tend to rot from the hull upwards. That's not always true, but generally, soft spots in the floor are a harbinger of bigger problems.

Get price

How to Repair Rot in a Deck or Balcony

30 · Rain Love AMR/Flickr/CC BY 2.0. Rotten wood deck railings and guards are especially dangerous because people using the deck depend on them for safety. Since most people using a deck assume that railings and guards are secure, they may lean against them with their full weight.. Remove rotten …

Get price

diy deck stairs repair rotted stringer repair

diy deck stairs repair rotted stringer repair. Rot Repair in Glass Boats - Epoxy products to repair and resist The wood you use for fill can be standard exterior grade ply which you will A clean professional repair in progress by one of our customers: Stringers were you are doing is building thin layers of epoxy in on and around the glass matrix.

Get price

How to repair or replace rotting deck posts?

7 · A second option would be to remove the rotted posts, fill the holes with concrete and install a metal plate over the concrete---since the filled holes will not be strong enough to support a new post and the load. Then use the post standoff …

Get price

How to Repair or Replace Rotted Deck Post

8 · The best way to repair rotted deck post is to replace it. If the post has been sunk into the ground and backfilled, you’ll need to excavate the entire post, remove it, and install concrete in a sonotube to above grade. You can then mount a new deck post and post bracket on top of the new concrete support. Replacing a deck …

Get price

Stringer Repairs in Fiberglass Boats

29 · Apply a liberal amount of thickened epoxy/404 High-Density or 406 Colloidal Silica mixture to one side of the contact area. Push the stringer in position with firm hand pressure. The epoxy mixture should squeeze out of the joint. Brace or tape the stringer in position as necessary.

Get price

How to Repair Rot in a Deck or Balcony

30 · Rain Love AMR/Flickr/CC BY 2.0. Rotten wood deck railings and guards are especially dangerous because people using the deck depend on them for safety. Since most people using a deck assume that railings and guards are secure, they may lean against them with their full weight.. Remove rotten …

Get price

How do you fix a rotten Stringer?

Repairing the Stringer Lift the stairs with a by brace on top of a hydraulic bottle jack to take the weight off of cracked or split stringers to make the repair possible. Apply a heavy duty mending plate, at least four inches long, to the bottom edge of the stair stringer spanning the damaged area.

Get price

Boat Stringer Repair Guide | BoatLIFE

In this boat stringer repair guide, we’ll look at what commonly goes wrong with and how to address it in the most straightforward, cost-effective way. What are Boat Stringers? Boat stringers refer to the wood underneath your boat deck that support said deck. Think of …

Get price

Fibreglass boat repair – replacing stringers

29 · Now you have successfully replaced the stringer, all that’s left to do is replace the fibreglass skin and your deck will, once again, be fully supported. If you’ve got a repair you’re unsure about, visit WSI’s dedicated support page for video tutorials, guides and …

Get price

Friscoboater's 1995 Sea Ray 220 BR Rotten Deck and ...

8 · Friscoboater's 1995 Sea Ray 220 BR Rotten Deck and Stringer Restoration This is the saga of my rotten boat story. If you have found this blog in the middle, please start …

Get price

How To Find Rotten Stringers and Deck | Boating Forum ...

 · Most notice a rotten floor by feeling 'soft spots' that give when you walk over them. If you find soft spots in the deck, you have a pretty good chance of having rot below the deck, as boats tend to rot from the hull upwards. That's not always true, but generally, soft spots in the floor are a harbinger of bigger problems.

Get price

Splits in stringer | DIY Home Improvement Forum

 · Combine my suggestion with Neal's. Shoot some adhesive in the crack. Pull together with a sideways screw. (sister)A block underneath the tread screwed to the rise. Screw the tread to the sistered blocking. That blocking probably won't split when you screw the …

Get price

how much would it cost to replace stringers and deck ...

 · Depending on the amount of damaged deck and how bad the stringers are, it may cost up to 10k to pay someone. you can do it yourself for about $2k in materials. you may need to split the hull and cap. However prior to this, first thing you should do is pull the second deck …

Get price

How do you fix a rotten Stringer?

Repairing the Stringer Lift the stairs with a by brace on top of a hydraulic bottle jack to take the weight off of cracked or split stringers to make the repair possible. Apply a heavy duty mending plate, at least four inches long, to the bottom edge of the stair stringer spanning the damaged area.

Get price

Transom, Stringer and Sole Repair

2 · a transom with a rotten core, there are several ways to handle the repair but only one good one. The best way is to get full access to the transom either by grinding down all the inside fiberglass skin or simply cut the whole thing out. Do not try to remove the rotten ply …

Get price

Boat Stringers Repairing and Replacing [Guide]

18 · One of the more common stringer repair methods is allowing the damaged area to dry and then injecting the epoxy. This might be an easier way, but not the most effective. You cannot see what is going on underneath the fiberglass skin, so the extent of the damage or rot …

Get price

2021 Deck Repair Costs | Fixing Boards, Mildew Damage & Rot

11 · The average cost of deck repair is $500, and total costs typically range from $250 to $1,200. Smaller repairs and fixes cost $48 to $150, and more extensive repairs cost $1,800 to $3,000.The total cost to repair a deck will depend on its size, the extent of the problem and the cost of the materials.

Get price

Repair Rotting Decking and Support Lumber, by James …

21 · Repair Rotting Decking and Support Lumber By James Dulley. J 4 min read. A- A+ . Dear James: The wood on my deck needs some repairs. ... Use an awl to probe any suspected rotten areas ...

Get price

contact info

© BEER Industrial Co., Ltd. All rights reserved